How to fix a Perkins 1106D Electric Power Generation (EPG) crank, but it won't start due to a high pressure fuel system failure.
Preparations:
Newest Perkins EST 2022A & 2019A Full Support Free Download
If you need,you can search on our store directly :www.obd2.ltd
Procedures:
1.Use the Perkins electronic service tool to check the absolute fuel rail pressure while the engine is cranking at a minimum speed of 150 rpm.
2.If the absolute fuel rail pressure is less than 25 MPa (3625 psi), perform the following
procedure:
a.Check that the inlet pressure at the fuel rail pump is greater than 50 kPa (7.25 psi). If the inlet pressure is less than 50 kPa (7.25 psi),repeat the diagnostic process from “Low Pressure Fuel System”.
b.Check for fuel leaks in the high pressure fuel system. Rectify any fuel leaks and then recheck the pressure in the fuel rail. If the fuel rail pressure is greater than 25 MPa (3625 psi),proceed to test step 3.
c.Use the electronic service tool to perform a solenoid test on the fuel rail pump. Refer to Troubleshooting, “Fuel Rail Pump Solenoid -Test”.
d.If any service has been performed as a result of Step 2.c, attempt to start the engine. If the engine will not start, repeat the diagnostic process from “Diagnostic Codes”.
e.Check the pressure relief valve in the fuel rail for leakage. If the pressure relief valve is leaking, replace the valve and recheck the pressure in the fuel rail.
f.If the pressure relief valve in the fuel rail is not leaking, check for fuel in the engine oil system. If fuel is suspected in the oil system,take an engine oil sample for analysis. Refer to Operation and Maintenance Manual, “Engine Oil Sample – Obtain”. If the analysis confirms that there is fuel in the engine oil system,investigate the cause.
g.If fuel is not found in the oil system, check the electronic unit injectors for excessive fuel leak off.
h.If the leak off is greater than 38 mL (1.3 oz) in 30 seconds for a 6 cylinder engine or the leak off is greater than 25 mL (0.85 oz) in 30 seconds for a 4 cylinder engine, replace the electronic unit injectors.
Note: The fault is not in the fuel rail pump. Do not replace the pump.
i.If the leak off is less than 38 mL (1.3 oz) in 30 seconds for a 6 cylinder engine or the leak off is less than 25 mL (0.85 oz) in 30 seconds for a 4 cylinder engine, proceed to Test Step 3.d.
3.If the absolute fuel rail pressure is greater than 25 MPa (3625 psi), perform the following procedure:
a.Use the electronic service tool to make sure that the status of the electronic unit injectors is not “Disabled”. If the injectors are disabled but the injectors were not intentionally disabled
with the electronic service tool, proceed to test step 3.d.
b.If the electronic unit injectors are not disabled,use the electronic service tool to perform an injector solenoid test. Refer to Troubleshooting,“Injector Solenoid Circuit – Test”.
c.If any service has been performed as a result of Step 3.b, attempt to start the engine. If the engine will not start, proceed to “Glow Plugs”.
d.Make sure that the latest flash file for the application is installed in the ECM. Refer to Troubleshooting, “Flash Programming”.
e.Contact Perkins Global Technical Support.
Note: This consultation can greatly reduce the repair time.
f.If Perkins Global Technical Support recommends the use of a test ECM, install a test ECM. Refer to Troubleshooting, “Replacing the ECM”.
g.Attempt to start the engine. If the engine will not start, install the original ECM and then proceed to Test Step 3.l.
h.If the engine starts normally, stop the engine and then attempt to start the engine again. If the engine will not start at the second attempt,proceed to Test Step 3.k.
If the engine starts normally, reconnect the suspect ECM and then verify that the fault returns when the suspect ECM is installed.
j.If the engine will not start with the suspect ECM, replace the ECM. Check that the engine starts normally. If the engine starts normally, no further testing is required.
k.Replace the ECM again and then replace the fuel rail pump. Verify that the fault has been eliminated. If the engine will not start, proceed to “Glow Plugs”.
l.Check the timing of the fuel rail pump. Refer to Systems Operation, Testing and Adjusting, “Fuel Injection Timing – Check”.
m.If the timing of the fuel rail pump required adjustment and the engine will not start,proceed to “Glow Plugs”.
n.If the timing of the fuel rail pump was correct,replace the fuel rail pump. If the engine will not start, proceed to “Glow Plugs”
Glow Plugs
Note: Faulty glow plugs will only affect engine starting when the ambient temperature is below 10 °C (50 °F).
1.Check the operation of the glow plugs.
2.If necessary, replace faulty glow plugs.
3.Attempt to start the engine. If the engine will not start, proceed to “Valve Lash”
Comment télécharger? / How to download? viewtopic.php?f=77&t=1294 Comment télécharger? / How to download? viewtopic.php?f=77&t=1294 Comment télécharger? / How to download? viewtopic.php?f=77&t=1294
All Autocom Delphi versions viewtopic.php?f=215&t=22381 VCDS all versions + Loader 03/2022 15GB viewtopic.php?f=203&t=18855 Xentry Passthru 06.2023 Full Patch + Activation viewtopic.php?t=23252 DTS Monaco 9.02 + Patch viewtopic.php?f=215&t=22221
Davinci Deluxe v1.0.30 / 2023 Registered viewtopic.php?f=215&t=23174 Tuning database 2019 for all cars 25GB viewtopic.php?f=216&t=20338 Multi Editor Tool v2 2023 + Patch viewtopic.php?f=216&t=22368 Easy Renault v6.1.4 FR + Activator viewtopic.php?f=212&t=22456
WinOLS Damos 2023 collection all car brands 24GB viewtopic.php?f=216&t=23669 Car Diagnostic Software Package 81 GB viewtopic.php?f=215&t=23209 Multiecuscan v5.1 + 5.0 + v4.9 / 2024 + Activator viewtopic.php?f=206&t=21696 Haynes Pro Full viewtopic.php?f=215&t=6793
RENAULT DIALOGYS 4.90 Français viewtopic.php?f=199&t=16332 Autodata 3.45 Français et Anglais viewtopic.php?f=202&t=3006 Jpro 2022 v2 + Activator viewtopic.php?f=215&t=24113 ElsaWin 6.0 Multilanguage viewtopic.php?f=190&t=12951
Renault Can Clip v237 + Activation 06.2024 viewtopic.php?f=212&t=24406 MaxiECU2 Full + License viewtopic.php?f=215&t=2393 Toyolex 4 Unlocked no need activation viewtopic.php?f=213&t=23442&p=135735 Immo Doctor v2.1 2023 + Patch viewtopic.php?f=216&t=22367
Selling / Vente: Activation Launch x431 EasyDiag Golo + ThinkDiag viewtopic.php?f=137&t=14064 Xentry OpenShell 12.2023 HHT (+C3) WIS EPC Vediamo Monaco viewtopic.php?f=196&t=13346 Remote Install BMW ISTA-D, ISTA-P, INPA, E-Sys viewtopic.php?f=137&t=14739
All Autocom Delphi versions viewtopic.php?f=215&t=22381 VCDS all versions + Loader 03/2022 15GB viewtopic.php?f=203&t=18855 Xentry Passthru 06.2023 Full Patch + Activation viewtopic.php?t=23252 DTS Monaco 9.02 + Patch viewtopic.php?f=215&t=22221
Davinci Deluxe v1.0.30 / 2023 Registered viewtopic.php?f=215&t=23174 Tuning database 2019 for all cars 25GB viewtopic.php?f=216&t=20338 Multi Editor Tool v2 2023 + Patch viewtopic.php?f=216&t=22368 Easy Renault v6.1.4 FR + Activator viewtopic.php?f=212&t=22456
WinOLS Damos 2023 collection all car brands 24GB viewtopic.php?f=216&t=23669 Car Diagnostic Software Package 81 GB viewtopic.php?f=215&t=23209 Multiecuscan v5.1 + 5.0 + v4.9 / 2024 + Activator viewtopic.php?f=206&t=21696 Haynes Pro Full viewtopic.php?f=215&t=6793
RENAULT DIALOGYS 4.90 Français viewtopic.php?f=199&t=16332 Autodata 3.45 Français et Anglais viewtopic.php?f=202&t=3006 Jpro 2022 v2 + Activator viewtopic.php?f=215&t=24113 ElsaWin 6.0 Multilanguage viewtopic.php?f=190&t=12951
Renault Can Clip v237 + Activation 06.2024 viewtopic.php?f=212&t=24406 MaxiECU2 Full + License viewtopic.php?f=215&t=2393 Toyolex 4 Unlocked no need activation viewtopic.php?f=213&t=23442&p=135735 Immo Doctor v2.1 2023 + Patch viewtopic.php?f=216&t=22367
Selling / Vente: Activation Launch x431 EasyDiag Golo + ThinkDiag viewtopic.php?f=137&t=14064 Xentry OpenShell 12.2023 HHT (+C3) WIS EPC Vediamo Monaco viewtopic.php?f=196&t=13346 Remote Install BMW ISTA-D, ISTA-P, INPA, E-Sys viewtopic.php?f=137&t=14739
How to repair Perkins 1106D electric power generation (EPG) cranks
Automotive Scan Tools and Vehicle Diagnostics for sale
* Publier votre annonce gratuitement
* Post your ad for free
* Publier votre annonce gratuitement
* Post your ad for free
- Lemoine88
- Lieutenant.
- Messages : 66
- Enregistré le : lun. 8 août 2022 04:06
- Réputation : 21
- A été remercié : 41 fois
- Sexe :
- Zodiaque :
- Contact :
How to repair Perkins 1106D electric power generation (EPG) cranks
Message par Lemoine88 » lun. 22 mai 2023 13:26
I'm a Capricorn and I prefer my job。www.obd2.ltd
Répondre
1 message
• Page 1 sur 1
Retourner vers « Vente Scanners et Outils Diagnostic Automobile »
Aller à
- Download Car / Truck GPS & Diagnostic Software
- ↳ Renault, Dacia, Opel et Vauxhall
- ↳ Attention ! Mise en Garde !
- ↳ Démonstration Mediaskin v2 et comparaison GPS Media Nav et Mediaskin
- ↳ MediaNav - Mise à Jour avec Upgrade et downgrade
- ↳ MediaNav - Installation du programme GPS
- ↳ MediaNav - Cartes GPS MediaNav à télécharger (Mise à jour en permanence)
- ↳ MediaNav - Autres fichiers gps
- ↳ MediaNav - Alerte Radars compatible avec media nav (Mise à jour en permanence)
- ↳ MediaNav - Personnalisation
- ↳ MediaNav - Installation Caméra de Recul sur Media Nav
- ↳ MediaNav - Réparation des Pannes et Documentation
- ↳ MediaNav - Réparation Pannes de Blocage sur Logo
- ↳ MediaNav - RGMaster3 SoftWares
- ↳ Mediaskin V2 et V3 - Installation avec Clé USB
- ↳ Mediaskin V2 - Installation sans Clé USB
- ↳ Mediaskin V2 - Installation des Thèmes ou Skins
- ↳ Mediaskin V2 - Réparation et Personnalisation
- ↳ Renault Dacia - Tutoriel Divers
- ↳ Renault / Dacia Tutoriels vidéos - Guide d'installation de la caméra de recul
- ↳ Renault / Dacia Tutoriels vidéos - Remise à zéro le voyant vidange du tableau de bord
- ↳ Autres Tutoriels vidéos
- ↳ R-Link / Renault
- ↳ R-Link 1
- ↳ R-Link 1 Tutoriels vidéos
- ↳ R-Link 2
- ↳ R-Link 2 Tutoriels vidéos
- ↳ Carminat / Renault
- ↳ Peugeot et Citroen
- ↳ Cartographies GPS
- ↳ Zones de danger avec cartographies GPS
- ↳ Firmwares - Mises à jours
- ↳ Identification des GPS
- ↳ Tutoriels
- ↳ Trucs et astuces
- ↳ GPS embarqués & firmwares / Autres Voitures
- ↳ Renault - Dacia
- ↳ Peugeot - Citroën
- ↳ Volkswagen - SEAT - SKODA
- ↳ BMW
- ↳ Mercedes
- ↳ Audi
- ↳ Kia
- ↳ GPS embarqués autres voitures
- ↳ GPS Android / iPhone / Windows CE, voitures et camions
- ↳ GPS Android / iPhone
- ↳ GPS Windows CE
- ↳ Logiciels de diagnostic voitures et camions
- ↳ Audi - Volkswagen- Seat - Skoda / Logiciels de Diagnostique
- ↳ Bmw / Logiciels de Diagnostique
- ↳ Buick - Cadillac - Chevrolet - GMC / Logiciels de Diagnostique
- ↳ Fiat - Lancia - Alfa Romeo / Logiciels de Diagnostique
- ↳ Ford - Land Rover - Jeep - Jaguar / Logiciels de Diagnostique
- ↳ Hyundai - Daewoo - Kia - SsangYong / Logiciels de Diagnostique
- ↳ Mercedes-Benz / Logiciels de Diagnostique
- ↳ Mitsubishi - Mazda - Suzuki - Daihatsu / Logiciels de Diagnostique
- ↳ Peugeot - Citroën / Logiciels de Diagnostique
- ↳ Renault - Dacia - Nissan / Logiciels de Diagnostique
- ↳ Toyota - Lexus - Honda / Logiciels de Diagnostique
- ↳ Volvo / Logiciels de Diagnostique
- ↳ Multimarques & Andriod OBD software / Logiciels de Diagnostique
- ↳ Multimarques, ECU - IMMO - Radio Code - Airbag / Logiciels de Diagnostique
- ↳ Documentation d'aide sur l'utilisation de l'outil de diagnostic
- ↳ Catalogue de pièces électroniques (EPC), RTA, manuel de maintenance et de diagnostic
- ↳ Catalogue de pièces électroniques (EPC) Automobile - Camion
- ↳ Audi - Volkswagen- Seat - Skoda / Logiciels
- ↳ Bmw / Logiciels
- ↳ Buick - Cadillac - Chevrolet - GMC / Logiciels
- ↳ Fiat - Lancia - Alfa Romeo / Logiciels
- ↳ Ford - Land Rover - Jeep - Jaguar / Logiciels
- ↳ Hyundai - Daewoo - Kia - SsangYong / Logiciels
- ↳ Mercedes-Benz / Logiciels
- ↳ Mitsubishi - Mazda - Suzuki - Daihatsu / Logiciels
- ↳ Peugeot - Citroën / Logiciels
- ↳ Renault - Dacia - Nissan / Logiciels
- ↳ Toyota - Lexus - Honda / Logiciels
- ↳ Volvo / Logiciels
- ↳ Multimarques / Logiciels
- ↳ E-book / Diagnostic, Mécanique et Revue Technique Auto
- ↳ Audi - Volkswagen- Seat - Skoda / Diag & Documentations
- ↳ Bmw / Diag & Documentations
- ↳ Buick - Cadillac - Chevrolet - GMC / Diag & Documentations
- ↳ Fiat - Lancia - Alfa Romeo / Diag & Documentations
- ↳ Ford - Land Rover - Jeep - Jaguar / Diag & Documentations
- ↳ Hyundai - Daewoo - Kia - SsangYong / Diag & Documentations
- ↳ Mercedes-Benz / Diag & Documentations
- ↳ Mitsubishi - Mazda - Suzuki - Daihatsu / Diag & Documentations
- ↳ Peugeot - Citroën / Diag & Documentations
- ↳ Renault - Dacia - Nissan / Diag & Documentations
- ↳ Toyota - Lexus - Honda / Diag & Documentations
- ↳ Volvo / Diag & Documentations
- ↳ Multimarques & Général Documents
- ↳ Diagnostic Général / Documentations
- ↳ Vente Scanners et Outils Diagnostic Automobile
- Softwares / Logiciels Win, iOS & APK
- Communauté motorcarsoft
- ↳ Signalez des problèmes
- ↳ Nouveautés, avis et suggestions à propos du site
- ↳ Discussions générales
- FAQ sur le forum
- Corbeille
- Nos partenaires