Cummins K19 Industrial and Marine Operation and Maintenance

Comment télécharger? How to download?
Cliquez ici / Click here Image viewtopic.php?f=77&t=1294
Règles du forum
Comment télécharger? How to download?
Cliquez ici / Click here Image viewtopic.php?f=77&t=1294
Répondre
Avatar du membre
rgmaster3
Capitaine de navire (Admin)
Capitaine de navire (Admin)
Messages : 64263
Enregistré le : ven. 29 sept. 2017 21:51
Réputation : 54184
Localisation : Îles Cocos
A remercié : 4752 fois
A été remercié : 42208 fois
Sexe :
Zodiaque : Taureau
Contact :

Cummins K19 Industrial and Marine Operation and Maintenance

Message par rgmaster3 » dim. 17 mai 2020 18:46

Image

Troubleshooting and Repair Manual
Electronic control systeme, C8.3 Marine Electronic Control System

Section i - Introduction
(99-204-002-tr) About the Manual
(99-204-003-tr) How to Use the Manual
(99-204-004) Symbols
(99-204-005) Illustrations
(99-204-006-tr) General Safety Instructions
(99-204-007-tr) General Repair Instructions
(99-204-008) General Cleaning Instructions
(99-204-009) Acronyms and Abbreviations

Section E - Engine and System Identification
(07-100-001) Engine Identification
(07-100-002-tr) Engine Diagrams

Section F - Familiarization
(07-101-007) Electronic Controlled Fuel System
(00-022-999) Service Tools and Hardware - Overview

Section TF - Troubleshooting Fault Codes
(07-fcmfc01) Fault Code Multiple A
(07-fcmfc02) Fault Code Multiple B
(07-fc111) Electronic Control Module Critical Internal Failure - Bad Intelligent Device or Component
(07-fc115) Engine Speed Sensor - Lost Primary Engine Speed Sensor
(07-fc121) Engine Speed Sensor - Lost Secondary Engine Speed Sensor
(07-fc122) Intake Manifold Pressure Sensor Circuit - Voltage Above Normal or Shorted to High Source
(07-fc123) Intake Manifold Pressure Sensor Circuit - Voltage Below Normal or Shorted to Low Source
(07-fc124) Intake Manifold Pressure High - Warning
(07-fc131) High Voltage Detected at the Throttle Position Signal Circuit
(07-fc132) Low Voltage Detected at the Throttle Position Signal Circuit
(07-fc133) Backup Throttle Position Sensor - Shorted High
(07-fc134) Backup Throttle Position Sensor - Shorted Low
(07-fc135) High Pressure Detected at the Oil Pressure Circuit
(07-fc141) Low Voltage Detected at the Oil Pressure Circuit
(07-fc143) Oil Pressure Signal Indicates Oil Pressure Below the Low Oil Pressure Engine Protection Limit
(07-fc144) High Voltage Detected at the Coolant Temperature Circuit
(07-fc145) Low Voltage Detected at the Coolant Temperature Circuit
(07-fc151) Coolant Temperature Signal Indicates Coolant Temperature Above 104°C [220°F]
(07-fc153) High Voltage Detected at the Intake Manifold Temperature Circuit
(07-fc154) Low Voltage Detected at the Intake Manifold Temperature Circuit
(07-fc155) Intake Manifold Temperature Signal Indicates Temperature Above 88°C [190°F]
(07-fc166) The Rack Position Sensor Indicates Rack Position is Greater than the Calibrated Threshold
(07-fc172) Fuel Rack is Stuck in a Position Commanding Excessive Fueling to the Engine
(07-fc173) Fuel Rack is Stuck in a Position Providing Adequate or Less than Adequate Fueling to the Engine
(07-fc237) Multi-Unit Sync Error
(07-fc497) Multi-Unit Sync Switch Error

Section TS - Troubleshooting Symptoms
(99-t00-001-tr) Troubleshooting Procedures and Techniques
(99-t00-002) Troubleshooting Symptoms Charts
(4021442-t033-tr) Engine Acceleration or Response Poor
(4021442-t043-tr) Engine Difficult to Start or Will Not Start (Exhaust Smoke)
(4021442-t044-tr) Engine Difficult to Start or Will Not Start (No Exhaust Smoke)
(4021442-t057-tr) Engine Power Output Low
(4021442-t061-tr) Engine Runs Rough at Idle
(4021442-t062-tr) Engine Runs Rough or Misfires
(4021442-t064-tr) Engine Shuts Off Unexpectedly or Dies During Deceleration
(4021442-t066-tr) Engine Speed Surges at Low or High Idle
(4021442-t067-tr) Engine Speed Surges Under Load or in Operating Range
(4021442-t072-tr) Engine Starts But Will Not Keep Running
(4021442-t080-tr) Engine Will Not Reach Rated Speed (RPM)
(4021442-t081-tr) Engine Will Not Shut Off
(4021442-t083-tr) Fault Code Warning Lamps Stay On (No Apparent Reason)
(4021442-t084-tr) Fault Code Warning Lamps Do Not Illuminate
(4021442-t087-tr) Fuel Consumption Excessive
(4021442-t116-tr) Smoke, Black — Excessive
(4021442-t118-tr) Smoke, White — Excessive

Section TT- Troubleshooting Symptoms (New Format)
(00-ttecm) ECM — No Communication Troubleshooting Tree

Section 19 - Electronic Engine Controls - Group 19
(07-022-001_19) Service Tools
(99-019-008) Battery Ground Circuit
(07-019-019) Engine Coolant Temperature Sensor
(99-019-027) Diagnostic Test Mode Switch
(99-019-028) Diagnostic Test Mode Switch Circuit
(07-019-031) Electronic Control Module (ECM)
(07-019-032) ECM Calibration Code
(07-019-042) Engine Speed Sensor (ESS)
(07-019-043) Engine Wiring Harness
(99-019-046) Fault Lamp
(99-019-047) Fault Lamp Circuit
(07-019-049) Fuel Shutoff Valve Circuit
(07-019-050) Fuel Shutoff Valve
(99-019-052) Idle Adjust Switch
(99-019-053) Idle Adjust Switch Circuit
(07-019-059) Intake Manifold Air Temperature Sensor
(07-019-061) Intake Manifold Pressure Sensor
(99-019-064) Key Switch Battery Supply Circuit
(07-019-066) Engine Oil Pressure Sensor
(99-019-085) Accelerator Pedal or Lever Position Sensor
(07-019-086) Accelerator Pedal or Lever Position Sensor Circuit
(07-019-087) Unswitched Battery Supply Circuit
(07-019-106) Engine Speed Sensor Circuit
(99-019-165) Data Link Circuit, SAE J1939
(99-019-166) Data Link Circuit, SAE J1587
(99-019-197) Ring Terminal
(99-019-198) Fuse, Harness In-Line
(99-019-199) Connector, Butt Splice
(99-019-201) Weather Pak Connector Series
(99-019-202) Metripack Connector Series
(99-019-203) AMP Connector Series
(99-019-204) Deutsch™ DRC Connector Series
(99-019-205) Deutsch™ DT Connector Series
(99-019-206) Deutsch™ DTM and DTP Connector Series
(99-019-207) Deutsch™ HD10 Connector Series
(99-019-208) Deutsch™ HDP20 and HD30 Connector Series
(99-019-209) ITT Cannon Connector Series
(99-019-210) AMP VP44 Connector Series
(99-019-211) Packard Relay Connector
(99-019-212) Ford™ Connector Series
(99-019-213) D-Sub Miniature Connector Series
(99-019-215) Bosch® ECM Injector Driver Connector Series
(99-019-216) Bosch® ECM Actuator and Sensor Connector Series
(99-019-217) Bosch® ECM OEM Connector Series
(99-019-218) Framatome Connector Series
(99-019-220) Augat Connector Series
(99-019-359) Multimeter Usage
(99-019-360) Resistance Measurement Using a Multimeter and a Wiring Diagram
(99-019-361) Component Connector and Pin Inspection
(99-019-362) Inactive or Intermittent Fault Code
(105-019-428) Engine Datalinks

Section L - Service Literature
(07-205-001) Additional Service Literature
(99-205-002) Service Literature Ordering Location
(99-205-004) Cummins Customized Parts Catalog

Section V - Specifications
(4021331) Specifications
(99-018-005) Drive Belt Tension
(99-018-009) Capscrew Markings and Torque Values
(99-018-010) Fraction, Decimal, Millimeter Conversions
(99-018-011) Newton-Meter to Foot-Pound Conversions
(99-018-012) Pipe Plug Torque Values
(99-018-013) Tap-Drill Chart - U.S. Customary and Metric
(99-018-014) Weights and Measures - Conversion Factors

:52:
Comment obtenir le mot de passe ou le lien de téléchargement ?
How do I get the password or download link?

Vidéo explicative: Image viewtopic.php?f=222&t=9976

Vous êtes un visiteur? Comment s'inscrire sur ce forum
You are a visitor? How to register on this forum

Cliquez ici / Click here Image viewtopic.php?f=77&t=296
Comment s'inscrire et prendre un abonnement?
How to register and take a subscription?
1.Comment s'inscrire sur le forum? / 1.How to register on the forum?
Image viewtopic.php?f=77&t=296
2.Comment prendre un compte premium? / 2.How To Take premium account?
Image viewtopic.php?f=77&t=1294
3.Comment rechercher sur le forum? / 3.How to search for the forum?
Image viewtopic.php?f=224&t=14788
4.Comment demander le lien de téléchargement et comment le recevoir par messagerie privée?
4.How to get the download link and how to receive it by private messaging?
Image viewtopic.php?f=222&t=9976

Compte d'abonnement
Subscription account
* Si votre compte donateur n'est pas activé! Contactez-nous par le formulaire de contact ci-dessous
* If your donor account is not activated! Contact us by the contact form below
Nous contacter / Contact us
Image memberlist.php?mode=contactadmin

Réglementation du téléchargement
Download rules
Image viewtopic.php?f=222&t=9976
* Remerciez l'auteur et notez positivement pour chaque application s'il vous plait.
* Deux téléchargements autorisés par jour.
* 15 téléchargements maximum, y compris trois packs (logiciels ou documents PDF).

* Thank the author and note positively for each application please..
* Two downloads authorized per day.
* 15 Downloads maximum, including three packs (software or PDF documents).

:405:

Répondre

255 derniers membres ayant consulté ce sujet

Avatar du membre Micka1306, Avatar du membre Maxx36, Avatar du membre topscan14, Avatar du membre rgmaster3

Retourner vers « Multimarques & Général Documents »